fbpx

DE605 GC (50 Hz) Generator Set

DE605 GC (50 Hz) Generator Set

Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Maximum Rating
605 kVA
Minimum Rating
605 kVA
Emissions/Fuel Strategy
Non Regulated
Voltage
380 to 415 Volts

Generator Set Specifications

Maximum Rating
605 kVA
Minimum Rating
605 kVA
Emissions/Fuel Strategy
Non Regulated
Voltage
380 to 415 Volts
Frequency
50 Hz
Speed
1500 rpm
Duty Cycle
Standby

Engine Specifications

Engine Model
C15 In-line 6, 4-cycle diesel
Bore
5.4in
Stroke
6.8in
Displacement
928in³
Compression Ratio
16.1:1
Aspiration
Turbocharged Air-to-Air Aftercooled
Fuel System
EUI
Governor Type
Adem™A4

Generator Set Dimensions

Length - Maximum
131in
Width - Maximum
60.6in
Height - Maximum
86.1in
Dry Weight - Genset (maximum)
8120lb

Standard Equipment:

  • Engine
    • Cat® C15 Inline 6 Cylinder, 4 Stroke Diesel
  • Control Panels
    • GCCP 1.1
  • Air Inlet
    • Air Cleaner
  • Governor
    • Mechanical Governor
  • Alternator
    • A Frame Standard Alternator
  • Cooling
    • Package mounted radiator
  • Fuel Storage
    • Single Wall 8 Hour Tank
  • Cooling System
    • Caterpillar Extended Life Coolant
    • Radiator and cooling fan with guards
    • Fan drive, battery charging alternator drive
  • Electrical Options
    • 3 Pole Circuit Breaker
    • Neutral Earth Link
    • 24 Volt battery with rack and cables
  • Fuel
    • Secondary fuel filter
    • Fuel priming pump
    • Primary fuel filter with integral water separator
  • Air Inlet System
    • Air cleaner; light duty with disposable element
  • Generator
    • IP23 Protection
    • Matched to the performance and output characteristics of Cat engines
    • Load adjustment module provides engine relief upon load impact and improves load acceptance and recovery time
  • Lube System
    • Lubricating oil
    • Oil drain line with valve
  • Mounting System
    • Captive linear vibration isolators
    • Lifting provision and drag points
  • General
    • Engine and alternator pre paint, Caterpillar yellow
    • Engine and alternator pre paint, Caterpillar yellow
  • Power Termination
    • Bus Bar
  • Generator And Attachments
    • Power center, IP22
    • Segregated low voltage (AC/DC) wiring panel
    • Mandatory Option circuit breaker, IEC, 3 pole, mounted in power centre
  • Mounting
    • Rubber vibration isolators
  • Governing System
    • Cat Electronic Governor (ADEM A4).
  • Lube System
    • Oil cooler
    • Oil drain valves
  • Mounting System
    • Captive linear vibration isolators between base and engine-generator includes lifting provisions and termination points for coolant and lube oil drain lines

Optional Equipment:

  • Exhaust
    • Industrial, Residential, Critical Mufflers
  • Control Panel
    • Speed and Voltage Adjust Potentiometers
    • PLG 4G/3G/Ethernet
    • Annunciator
    • Emergency E-Stop
  • Enclosure
    • Cat GC Enclosure
  • Generator
    • Anti-condensation heater
    • Excitation: [ ] Permanent Magnet Excited (PM) [ ] Internally Excited (IE)
    • Oversize and premium generators
  • Electrical Options
    • 4 Pole circuit breaker
    • Auxiliary Contacts
    • Pad-lockable circuit breaker
    • Battery Charger
    • Wet Battery
  • Power Termination
    • Circuit breakers, IEC compliant
    • Circuit breakers, UL listed
  • Alternator
    • Space Heater
    • AVR
  • Fuel System
    • Dual Wall 8Hr Fuel Tank
    • Single Wall 8Hr Fuel Tank with Spill Containment
    • Low Fuel Level Shutdown
    • Low and High Fuel Level Alarms
    • Manual fuel transfer pump
    • Fuel transfer system controls
    • Dual wall fuel tank base
  • Generator And Attachments
    • Oversize A frame generator
    • LC frame CIP generator
    • Permanent magnet generator
    • Space heaters
    • Ingress protection
    • LC frame generator
    • A frame generator - IP21 Protection
    • CIP a frame generator
    • Oversize LC frame generator
  • Starting/charging
    • Charging alternator
    • Jacket water heater
    • Battery chargers
    • Oversize batteries
    • Heavy-duty starting system
    • 24 Volt battery with rack and cables
  • Air Inlet System
    • Single Stage Air Filter
    • Dual Element Air Filter
  • Certifications
    • EU certificate of conformance
    • EAC certification
  • General
    • Automatic transfer switches (ATS)
    • EEC Declaration of Conformity
    • Integral & sub-base UL listed dual wall fuel tanks
    • Single or dual wall sub-base fuel tanks
    • Seismic Certification per applicable building codes: IBC 2000, IBC 2003, IBC 2006, IBC 2009, CBC 2007
    • CSA Certification
    • UL 2200 package
    • The following options are based on regional and product configuration:
    • Single or dual wall integral fuel tanks
    • EU Certificate of Conformance (CE)
    • Sound attenuated, weather protective or high ambient weather protective enclosure
    • Narrow, Wide or Skid Base
  • Extended Service Coverage
    • 3, 4, 5 and 10 Years
  • Enclosures
    • High ambient sound attenuated enclosures
  • Exhaust System
    • Industrial Silencer
    • 10 dBA Attenuation silencer
    • Manifold and turbocharger guard
    • End in / End out mufflers - 10, 25 and 35 dBA attenuation
    • Flexible exhaust fittings
    • 6 and 8 inch elbow kit
    • 6 and 8 inch flange GP
    • Engine mounted muffler
  • Lube System
    • Manual sump pump
  • Mounting System
    • Narrow skid base - replaces standard fuel tank base
  • Special Test / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
  • Starting / Charging System
    • 5 Amp single battery charger
    • Battery disconnect switch
    • Jacket water heater

Specifications

Generator Set Specifications

Maximum Rating
605 kVA
Minimum Rating
605 kVA
Emissions/Fuel Strategy
Non Regulated
Voltage
380 to 415 Volts
Frequency
50 Hz
Speed
1500 rpm
Duty Cycle
Standby

Engine Specifications

Engine Model
C15 In-line 6, 4-cycle diesel
Bore
5.4in
Stroke
6.8in
Displacement
928in³
Compression Ratio
16.1:1
Aspiration
Turbocharged Air-to-Air Aftercooled
Fuel System
EUI
Governor Type
Adem™A4

Generator Set Dimensions

Length - Maximum
131in
Width - Maximum
60.6in
Height - Maximum
86.1in
Dry Weight - Genset (maximum)
8120lb

Standard/Optional Features

Standard Equipment:

  • Engine
    • Cat® C15 Inline 6 Cylinder, 4 Stroke Diesel
  • Control Panels
    • GCCP 1.1
  • Air Inlet
    • Air Cleaner
  • Governor
    • Mechanical Governor
  • Alternator
    • A Frame Standard Alternator
  • Cooling
    • Package mounted radiator
  • Fuel Storage
    • Single Wall 8 Hour Tank
  • Cooling System
    • Caterpillar Extended Life Coolant
    • Radiator and cooling fan with guards
    • Fan drive, battery charging alternator drive
  • Electrical Options
    • 3 Pole Circuit Breaker
    • Neutral Earth Link
    • 24 Volt battery with rack and cables
  • Fuel
    • Secondary fuel filter
    • Fuel priming pump
    • Primary fuel filter with integral water separator
  • Air Inlet System
    • Air cleaner; light duty with disposable element
  • Generator
    • IP23 Protection
    • Matched to the performance and output characteristics of Cat engines
    • Load adjustment module provides engine relief upon load impact and improves load acceptance and recovery time
  • Lube System
    • Lubricating oil
    • Oil drain line with valve
  • Mounting System
    • Captive linear vibration isolators
    • Lifting provision and drag points
  • General
    • Engine and alternator pre paint, Caterpillar yellow
    • Engine and alternator pre paint, Caterpillar yellow
  • Power Termination
    • Bus Bar
  • Generator And Attachments
    • Power center, IP22
    • Segregated low voltage (AC/DC) wiring panel
    • Mandatory Option circuit breaker, IEC, 3 pole, mounted in power centre
  • Mounting
    • Rubber vibration isolators
  • Governing System
    • Cat Electronic Governor (ADEM A4).
  • Lube System
    • Oil cooler
    • Oil drain valves
  • Mounting System
    • Captive linear vibration isolators between base and engine-generator includes lifting provisions and termination points for coolant and lube oil drain lines

Optional Equipment:

  • Exhaust
    • Industrial, Residential, Critical Mufflers
  • Control Panel
    • Speed and Voltage Adjust Potentiometers
    • PLG 4G/3G/Ethernet
    • Annunciator
    • Emergency E-Stop
  • Enclosure
    • Cat GC Enclosure
  • Generator
    • Anti-condensation heater
    • Excitation: [ ] Permanent Magnet Excited (PM) [ ] Internally Excited (IE)
    • Oversize and premium generators
  • Electrical Options
    • 4 Pole circuit breaker
    • Auxiliary Contacts
    • Pad-lockable circuit breaker
    • Battery Charger
    • Wet Battery
  • Power Termination
    • Circuit breakers, IEC compliant
    • Circuit breakers, UL listed
  • Alternator
    • Space Heater
    • AVR
  • Fuel System
    • Dual Wall 8Hr Fuel Tank
    • Single Wall 8Hr Fuel Tank with Spill Containment
    • Low Fuel Level Shutdown
    • Low and High Fuel Level Alarms
    • Manual fuel transfer pump
    • Fuel transfer system controls
    • Dual wall fuel tank base
  • Generator And Attachments
    • Oversize A frame generator
    • LC frame CIP generator
    • Permanent magnet generator
    • Space heaters
    • Ingress protection
    • LC frame generator
    • A frame generator - IP21 Protection
    • CIP a frame generator
    • Oversize LC frame generator
  • Starting/charging
    • Charging alternator
    • Jacket water heater
    • Battery chargers
    • Oversize batteries
    • Heavy-duty starting system
    • 24 Volt battery with rack and cables
  • Air Inlet System
    • Single Stage Air Filter
    • Dual Element Air Filter
  • Certifications
    • EU certificate of conformance
    • EAC certification
  • General
    • Automatic transfer switches (ATS)
    • EEC Declaration of Conformity
    • Integral & sub-base UL listed dual wall fuel tanks
    • Single or dual wall sub-base fuel tanks
    • Seismic Certification per applicable building codes: IBC 2000, IBC 2003, IBC 2006, IBC 2009, CBC 2007
    • CSA Certification
    • UL 2200 package
    • The following options are based on regional and product configuration:
    • Single or dual wall integral fuel tanks
    • EU Certificate of Conformance (CE)
    • Sound attenuated, weather protective or high ambient weather protective enclosure
    • Narrow, Wide or Skid Base
  • Extended Service Coverage
    • 3, 4, 5 and 10 Years
  • Enclosures
    • High ambient sound attenuated enclosures
  • Exhaust System
    • Industrial Silencer
    • 10 dBA Attenuation silencer
    • Manifold and turbocharger guard
    • End in / End out mufflers - 10, 25 and 35 dBA attenuation
    • Flexible exhaust fittings
    • 6 and 8 inch elbow kit
    • 6 and 8 inch flange GP
    • Engine mounted muffler
  • Lube System
    • Manual sump pump
  • Mounting System
    • Narrow skid base - replaces standard fuel tank base
  • Special Test / Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
  • Starting / Charging System
    • 5 Amp single battery charger
    • Battery disconnect switch
    • Jacket water heater